Service & Parts ManualConvotherm Combination Oven-Steamer MODELS: Electric 10.10 and 6.20OEB-10.10OES-10.10OEB-6.20OES-6.2007061333 East 179th St
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
Figure 4-1a Control Panel CONTROL PANEL BASIC OPERATION A. QUICK START GUIDE ALWAYS PRE-HEAT THE OVEN CHAMBER! 1. Switch on with key (1). 2. Se
Figure 4-1b Control Panel B. CONTROL PANEL DETAIL VIEW Note: Item numbers correspond to numbers on the control panels in Figure 4-1b 1. ON/OFF When
Table of ContentsInstallation For the Installer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1Warranty .
Function Indicators • Light up when function or activity is engaged: 10. Reduced Power 11. Burner or Electric Heating ON 12. Reduced Fan Speed 13. Co
CAUTION Clean the oven chamber at least once per day or more frequently as needed Failure to clean the Combi properly and regularly can cause equipmen
CAUTION Do NOT use U-Shaped racks that are bent or otherwise damaged in any way. Pans and accessories placed in damaged racks can tip and spill, causi
Drain Cover and Drain e. Clean the Bypass Measuring Aperture. (Opening in the oven chamber on the left-hand side, slightly below the door latch. See
B. Semi-Automatic Cleaning of the Oven Chamber NOTE: Do NOT press the Start/Stop key while using the Semi-automatic Cleaning process. This stops the
a. The third step is Steam mode at 86°F for 1 minute. No action is needed. b. The fourth step is Steam at 212°F for 10 minutes, followed by a Signal
CAUTION Always make sure the cleaning agent containers are correctly connected to the Combi CONVOClean => RED CONVOCare => BLUE or WHITE C. CON
3 “Strong Soiling” 2 hours. 4 ‘Strong Soiling – Shining+” 2 hours and 45 minutes. 8. Press the Smart Key. 9. “Food inside oven?” appears in t
CAUTION Use ONLY the DISSOLVE® Descaler method using Part No. 106174 to descale the Combi. Read, understand, and follow both the descaling procedure i
WARNING This procedure is slightly different depending on the model being descaled. This entire procedure should be read and fully understand as it a
Table of Contents (continued)Service Parts Pump, Steam Generator, Electric, (OEB 6.20 & 10.10). . . . . . . . . . . . . . 53(continued) Door (OES
• While adding liquid to the steam generator through the descaler inlets, pour slowly to avoid overflow. • Wipe up any spills at once to avoid etching
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115483 ASSEMBLY, PANEL, RIGHT SIDE, 10.10 2 1 C2114824 ASSEMBLY/WELDMENT,
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115483 ASSEMBLY, PANEL, RIGHT SIDE, 10.10 2 1 C2114824 ASSEMBLY/WELDMENT,
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115482 ASSEMBLY, PANEL, RIGHT SIDE, 6.20 2 1 C2114826 ASSEMBLY/WELDMENT,
51 52 24596728 165518130325231 57 12 134442432248455049582147462620603739385023414010929251453 819332734 36223113517565461415C3216313 B0706620 ELEC IN
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115482 ASSEMBLY, PANEL, RIGHT SIDE, 6.20 2 1 C2114826 ASSEMBLY/WELDMENT,
CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVELAND RANGE.THI
INSTALLATION ALL SERVICE MUST BE PERFORMED BY A QUALIFIED CLEVELAND RANGE AUTHORIZED TECHNICIAN. The Installation Manual is a p
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C5115400 PANEL, ELECTRICAL COMPONENT 6.10/6.20/10.102 4 111601 DIN RAIL 8.375"
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114297 WELDMENT, CONTROL PANEL2 1 C5019101 CONTROLLER, 5010 OPERATING MODULE3 1
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114520 OUTER BASE, EL, 6.10/10.102 1 C2216088 AIR INLET BOX FINAL ASSEMBLY3 1 C
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114520 OUTER BASE, EL, 6.10/10.102 1 C2114699 ASSEMBLY, TOP COVER, PUMP HOUSING,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114520 OUTER BASE, EL, 6.10/10.102 1 C2114699 ASSEMBLY, TOP COVER, PUMP HOUSING,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114522 ASSEMBLY, OUTER PLATE EL 6.20/10.203 1 C5011003 CONNECTION FLANGE4 1 C20
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114522 ASSEMBLY, OUTER PLATE EL 6.20/10.202 1 C2114699 ASSEMBLY, TOP COVER, PUMP
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115380 WELDMENT, OUTER BASE, ELECTRIC & GAS INJ, 6.10/10.102 4 111604 FOOT, 6
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C6015215 ELBOW, HOSE CONNECTION, 3/8" WITH SEAL2 2 111647 CLAMP, OETIKER, S/S,
Cleveland STATEMENT OF POLICIES L I M I T E D W A R R A N T Y CLEVELAND RANGE products are warranted to the original purchaser to be free from defec
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300453 VALVE ASSEMBLY, 3WAY 240VAC2 3 111498 HOSE, SILICONE, 3/8" ID (SPECIFY L
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300457 VALVE ASSY. 2 WAY 240VAC2 2 111498 HOSE, SILICONE, 3/8" ID (SPECIFY LEN
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300457 VALVE ASSY. 2 WAY 240VAC2 4 111498 HOSE, SILICONE, 3/8" ID (SPECIFY LENG
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300453 VALVE ASSEMBLY, 3WAY 240VAC300363 TRIPLE SOLENOID VALVE 110-120V 50/60 Hz 180º
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300453 VALVE ASSEMBLY, 3 WAY 240VAC (OES 6.20)2 3 300407 FILTER, ELECTRICAL3 6 3005
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2314217 WELDMENT, GEN, ELEC 6.20/10.102 1 C2314243 SUPPORT, STEAM GEN, TABLE TOP U
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2314207 ASSEMBLY INSTRUCTION, STM GEN, ELEC, HEATER SELECTION, 6.20/10.102 1 C23142
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C6015100 DRAIN ELBOW FOR STEAM GENERATOR2 1 C6005299 SUPPORT BUSHING, STEAM GENERATO
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2514358 ASSEMBLY, OUTER DOOR, 6.201 C2514359 ASSEMBLY, OUTER DOOR, 10.102 1 C2514
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2614806 CARRIAGE PLATE, WELDED, 6.20C2614807 CARRIAGE PLATE, WELDED, 10.10 & 10.
GENERAL INFORMATION ABOUT COMBIS A. PRODUCT INFORMATION Cleveland Range, LLC assigns two product identification numbers to each Combi: a model nu
AEDDEBCINSTALLEDORIENTATIONSECTION E-EDETAIL CDETAIL B DETAIL ASECTION D-D4119 20 81472113 214216182011 211017172214 213 961558 14418C2614801 B, C2614
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2514351 DOOR, 6.20, COMPLETE- 1 C2514352 DOOR, 10.10, COMPLETE2 1 C2114652 WELDMENT, COR
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C3216201 WELDMENT, STAND, COMBI, 6.10/10.102 2 100413 FOOT ASS'Y, ADJUSTABLE (
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C3416377 WELDMENT, BASE, STACKING KIT, GAS, 6.20/10.202 1 C3416369 WELDMENT, EXHAUS
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1* 1 C3416368 WELDMENT, BASE, STACKING KIT, ELECTRIC, 6.10/10.102* 1 C3416362 SHROUD, S
CLEVELAND RANGE OEB 6.20/10.10SEQUENCE OF OPERATIONSWhen using these instructions refer to the OEB 6.20/10.10 wiring schematic.1 When incoming power
INSTALLATION INSTRUCTIONS A. GENERAL This equipment should be installed only by qualified, professional plumbers, pipe fitters, and electricians.
• If the ground is not found 220 VAC is sent from terminal 7 on connector X12on the Control Board (A10) to the fill solenoid (Y3)• The fill solenoid
• For the first 2 minutes 220 VAC is sent from terminal 4 on connector X11through the normally closed auxiliary contacts of contactor K5 to the K50co
5 With the combi in the Hot Air mode with time on the timer, the door closed and thestart switch is depresseda The front display will include a ligh
◊ The normally closed auxiliary contact of K4 opens preventing the SteamContactor K1 from energizing • 220 VAC is sent from terminal 7 of connector
• For the first 2 minutes 220 VAC is sent from terminal 4 on connector X11through the normally closed auxiliary contacts of contactor K5 to the K50co
◊ The contactor K44 closes and the third leg of 220 VAC is sent to the 18KW element (E4)◊ If the reduced power option is chosen then the K44 Contact
• For 15 seconds the motor is de-energized and allowed to coast.• For the next 2 minutes 220 VAC is sent from terminal 3 on connector X11through the
e When the condensate box is heated to 140 degrees F at the B3probe, 220 VAC issent from terminal 5 of connector X12 to the condenser valve (Y1) unti
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
B. INSTALLATION OF THE COMBI – General Instructions General Instructions: 1. Select the Combi’s operating location. 2. Complete the water, dra
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA1 2 34 5 6 78FEDCBA1 2 34 5 6 78CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET O
FEDCBA1 2 34 5 6 78FEDCBA1 2 34 5 6 78CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET O
CLEVELAND RANGE OES 6.20/10.10SEQUENCE OF OPERATIONSWhen using these instructions refer to the OES 6.20/10.10 wiring schematic.1 When incoming power
• If the combi fan is in the reduced setting 220 VAC is sent from terminal 6 onconnector X11 through the normally closed auxiliary contacts of contac
e When the condensate box is heated to 140 degrees F at the B3 probe, 220 VAC issent from terminal 5 of connector X12 to the condenser valve (Y1) unt
• 220 VAC is sent from terminal 3 of connector X12 on the Control Board(A10) through the normally closed auxiliary contacts of K2 and K1 to the coilo
◊ The K57 contactor closes Sending 220 VAC through the Q57 thermaloverload to the motor and the motor turns at a reduced speed.◊ The normally closed
C. SPECIAL INSTRUCTIONS FOR CASTER EQUIPPED COMBI STANDS AND COMBIS 1. Read all instructions before beginning installation. 2. Level the floor
◊ In the light and medium modes (one and two drops in the display) the Y2valve will be energized until the bypass probe (B5) is satisfied.◊ In the f
• 220 VAC is sent from terminal 3 of connector X12 on the Control Board(A10) through the normally closed auxiliary contacts of K2 and K1 to the coilo
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
-M1M 3~1U / BK2U / WHGNDFANBK 12/A2-Q56:13RD 18RD 18GYGY-X13.2-X13.1321321548761V / BU1W / BN2V / YE2W / RD99-X13GN2/5.C5-A10:X11:145678-K57135246/3.E
MBM 5010-M3.1-Y1-F2.1-A13-X10-X10-X10-S7-S2-X10-Y10-Y20-Y22-Y23-A11-X10:20/2.E1-X10:DC8/2.E1-X10:20/2.B8-K0:A1/3.C3-X10:31/3.D2-G1:12V/3.D2-G1:0V/4.F4
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
Commentaires sur ces manuels