Cleveland-range SteamChef 22CGT3 Manuel d'utilisateur

Part No. 22CGT-INM REV.A 2/07 Installation Manual Installation and Maintenance Instructions Steam Cooker and Rethermalization Unit Series: Stea

4 CHAPTER 3 INSTALLATION of the SteamChef A. Selecting a Location for the SteamChef 1. For safe and efficient operation, observe the following crit

5 Figure 3-2 SteamChef on Foam Packing Blocks, Front View Improper lifting can result in DEATH, INJURY, AND EQUIPMENT DAMAGE. Use enough workers wi

6 FIRE OR EXPLOSION HAZARD LEAKING GAS CAN CAUSE FIRE OR EXPLOSION. GAS LEAKS ARE FIRE AND EXPLOSION HAZARDS. INJURY, DEATH, AND PROPERTY DAMAGE WI

7 3. Testing Gas Supply Lines 1) Test all pipe joints for leaks with soap and water solution. 2) Check all connections for proper tightness. 3) R

8 2. Connection of the Water Supply Lines • The Installer/Owner is responsible for the correct water connection of the SteamChef. • When connect

9 Water Reservoir Pressure Reducer(if required)Main Water Shut Off ValveMain ColdWater SupplyAir/Water Column (if required) Check ValveFilter Washer

10 SteamChefMAIN EXTERNALPOWER SWITCH• The fuse or breaker and disconnect switch combination is called the “Main External Power Switch.” See Figure

11 8. Do NOT connect the SteamChef drain directly to drains or to the plumbing of any other equipment. 9. Do NOT install a trap or shutoff in the

12 The fan guard helps protect the operator from injury caused by the rotating fan blades. Never operate a SteamChef without the fan guard properly

13 L. Installation Check List Table 2-4 Installation Check List TASK REFERENCE COMPLETED (Page Number) Preparation • Check

NOTICEPost instructions to be followed if the user smells gas. Display the instructions in a prominent location. All users of this equipment must un

14 CHAPTER 3 STARTUP PROCEDURE A. In the Event of a Power Failure • Do NOT attempt to operate a S

15 B. Lighting and Shutdown Instructions • Refer to the Operator’s Manual for complete operating and safety instructions. • This procedure should

16 e) After the cooking compartment door is closed and the water reservoir is filled to the operating level, the igniter spark initiates and the aut

17 CHAPTER 4 OPERATING TESTS This procedure evaluates the function of the major operating controls of a SteamChef. • The SteamChef may be equipped w

18 C. Operating Tests (Continued from Drain Rinse Inspection) 1. At the start of this test the cooking compartment door should be open and the cont

19 Note: After 60 minutes of uninterrupted operation of both the Timer model SteamChefs in Manual Mode, and ON/OFF model SteamChefs turned ON, the St

20 D. Shutdown of the SteamChef after Testing (Continued from Operating Tests) and Front Burner Cover Installation 1. Turn the SteamChef OFF by tur

21 Figure 4-1 Front Burner Cover Installation Note: The Front Burner Cover is shipped loose. To Install the Front Burn

Cleveland STATEMENT OF POLICIES L I M I T E D W A R R A N T Y CLEVELAND RANGE products are warranted to the original purchaser to be free from def

INSTALLATION MANUAL SteamChef MODELS 22CGT3 AND 22CGT6 TABLE OF CONTENTS Chapter Page1 PRODUCT INFORMATION ABOUT 22CGT3 and 22CGT6 SteamChefs……………

INSTALLATION MANUAL SteamChef MODELS 22CGT3 AND 22CGT6 TABLE OF CONTENTS (CONTINUED) 3 STARTUP PROCEDURE………………………………………………………………….…. 14 A. In th

1 Figure 1-1 Do NOTLift from Sides CHAPTER 1 PRODUCT INFORMATION for 22CGT3 and 22CGT6 SteamChefs A. Product Information This manual covers the ins

2 Improper lifting can result in DEATH, INJURY, AND EQUIPMENT DAMAGE. Use enough workers with training and experience lifting heavy equipment to plac

3 Dimensions and Clearances 22CGT3&6 Figure 2-1 1834215825111632316217o2228116111162421584231612375169335014OPERATING CLEARANCE18116SERVICECLEARA